C15 Generator Set

Duty Cycle	Standby, Prime
Emissions/Fuel Strategy	Low Fuel, Tier 2, Tier 3, EU Stage IIIA
Frequency	60 Hz
Maximum Rating	500 ekW
Minimum Rating	320 ekW
Speed	1800 rpm
Voltage	208 to 600 Volts

Aspiration	Air to Air Aftercooled
Bore	5.4in
Compression Ratio	16.1:1
Displacement	927.56in³
Engine Model	C15 ATAAC, I-6, 4-Stroke Water-Cooled Diesel
Fuel System	MEUI
Governor Type	Adem™A4
Stroke	6.75in

Height - Maximum	82.4in
Length - Maximum	168.2in
Width - Maximum	81in

Standard Equipment:

Turbocharger
Air Cleaner - Non Canister disposable paper filter
Aftercooler core

Air Cleaner

EMCP 4.2
EMCP 4 Genset Controller

Package mounted radiator

Coolant drain line with valve
Fan drive, battery charging alternator drive
Caterpillar Extended Life Coolant
Radiator and cooling fan with guard

Base, formed steel with single wall integral 8-hour fuel tank
Standard open set fuel tank / base supplied
Exhaust flange outlet

Primary fuel filter with integral water separator
Secondary fuel filter
Fuel priming pump

Engine fuel transfer pump
Flexible fuel lines
Fuel cooler
Fuel priming pump
Primary fuel filter w/integral water separator & secondary filter

IP23 Protection
Load adjustment module provides engine relief upon load impact and improves load acceptance and recovery time
Matched to the performance and output characteristics of Cat engines

Bus Bar

Rubber vibration isolators

Segregated low voltage (AC/DC) wiring panel
Optional LC frame generator - IP23 Protection
Power center, IP22
Mandatory Option circuit breaker, IEC, 3 pole, mounted in power centre
Integrated Voltage Regulator
A frame generator - IP21 Protection

Cat Electronic Governor (ADEM A4).

Oil drain valves
Oil cooler

Captive linear vibration isolators between base and engine-generator includes lifting provisions and termination points for coolant and lube oil drain lines

24 Volt battery with rack and cables
24 volt starting motor
Batteries

Engine and alternator pre paint, Caterpillar yellow
Paint - Caterpillar Yellow except rails and radiators gloss black

Optional Equipment:

Single element air cleaner
Dual element air cleaner

Industrial, Residential, Critical Mufflers

Global certification for CIS
EU certificate of conformance

Anti-condensation heater
Excitation: [ ] Permanent Magnet Excited (PM) [ ] Internally Excited (IE)
Oversize and premium generators

4 Pole (IEC-100% rated) circuit breakers - Package mounted
Power terminal strip
4 Pole (IEC-100% rated) circuit breakers - Motorised
Shunt trip for IEC circuit breaker
Pad-lockable circuit breaker device
Auxiliary contacts, circuit breaker
3 Pole (IEC-100% rated) circuit breakers - Motorised
3 Pole (IEC-100% rated) circuit breakers - Package mounted

Circuit breakers, IEC compliant
Circuit breakers, UL listed

Remote annunciator
Local alarm horn
Local annunciator
Oil temperature displays
EMCP 4.3, EMCP 4.4
Volt free contacts
Protective devices: Earth fault relay ; Earth leakage ground fault relay ; Overload shutdown via breaker ; Low fuel level alarm ; Low fuel level shutdown ; High fuel level alarm ; Fuel level sensor

Charging alternator
Battery chargers
Oversize batteries
Heavy-duty starting system
Jacket water heater

Low coolant temperature alarm
Stone guards
Radiator duct flange

Sound attenuated enclosures
High ambient sound attenuated enclosures

Engine mounted muffler
6 and 8 inch elbow kit
Manifold and turbocharger guard
End in / End out mufflers - 10, 25 and 35 dBA attenuation
6 and 8 inch flange GP
Flexible exhaust fittings

Fuel transfer system controls
Manual fuel transfer pump
Dual wall fuel tank base

Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007
Sound attenuated, weather protective or high ambient weather protective enclosure
EU Certificate of Conformance (CE)
Single or dual wall integral fuel tanks
CSA Certification
EEC Declaration of Conformity
Narrow, Wide or Skid Base
Integral & sub-base UL listed dual wall fuel tanks
Automatic transfer switches (ATS)
UL 2200 package
The following options are based on regional and product configuration:
Single or dual wall sub-base fuel tanks

Oversize LC frame generator
Oversize A frame generator
CIP a frame generator
LC frame generator
LC frame CIP generator
Ingress protection
Permanent magnet generator
Space heaters

Manual sump pump

Narrow skid base - replaces standard fuel tank base

PGS Test report @ 1.0 power factor
PGS Test report @ 0.8 power factor

5 Amp single battery charger
Battery disconnect switch
Jacket water heater

What Our Customers Are Saying About Us

Gregory Poole Equipment Company

4.0

Based on 58 reviews

review us on

Tom Corona

3 months ago

Rich Stidd

3 months ago

Carlos Virgilio Sauceda Rivera

4 months ago

John Karpathian

6 months ago

Clean store and great employees

Hunter Flaugher

12 months ago

Hydraulic pump shop is unmatched. I made the mistake of going somewhere else before bringing my pump here. These guys were more than helpful and friendly. Went out of their way to help me find a solution for my problem even when it didn’t benefit them. This is how businesses should be run. I won’t go anywhere else.

Brian Hrudka

1 year ago

Too bad Poole Cat Field Service is better at invoicing than actually getting my machines moving.

A prompt and courteous technician arrived, and correctly diagnosed two problems with my mini Ex. Thank you. I corrected those problems, but machine still did not work.

He diagnosed a fuel problem as a clogged filter, rather than a bad fuel pump which I managed to diagnose. I also figured out, via help on the internet, that the fuel shut-off solenoid was bad.

Machine runs fine now. So my advice is to check the internet, before letting Poole charge you $870 for a two hour field visit. And you can find a perfectly fine aftermarket fuel pump for $20 rather than the $250 that Poole charges... and it arrives faster,

Jacey Price

2 years ago

Need to teach a tech how to drive a service truck. Around 2:48 on highway 40 east, the truck pictured (plate ending in 8236) flew across 3 lanes of traffic to meet the Cleveland rd exit. Almost hit a semi and caused me to swerve with my children in the car. Glad making the exit was more important than children’s lives.