3512 Generator Set | gregorypoole

Duty Cycle	Standby, Mission Critical, Prime, Continuous
Emissions/Fuel Strategy	Low Fuel Consumption
Frequency	50 Hz
Maximum Rating	1400 kVA
Minimum Rating	1000 kVA
Prime Power Rating	1275/1150 kVA
Speed	1500 rpm
Standby Rating	1400/1250 kVA
Voltage	380 to 415 Volts

Aspiration	TA
Bore	6.69in
Compression Ratio	13.5:1
Displacement	3161.03in³
Engine Model	3512 TA, V-12, 4-Stroke Water-Cooled Diesel
Fuel System	Direct Unit Injection
Governor Type	Woodward
Stroke	7.48in

Dry Weight - Genset (maximum)	23170lb
Dry Weight - Genset (minimum)	22650lb
Height - Maximum	93.2in
Length - Maximum	206.6in
Length - Minimum	202.7in
Width - Maximum	77.8in

Standard Equipment:

Air Inlet System
- Air cleaner; single element canister type with service indicator
Control Panel
- EMCP4.2B controls including: Emergency stop pushbutton
- RPM
- Engine cool-down timer
- EMCP4.2B controller including:
- Accessory module data link
- 4 programmable relay outputs (Form A)
- Communications:
- Volts (L-L & L-N)
- Over / under frequency (81 o / u)
- Text alarm / event descriptions
- Auto / start / stop control
- Speed adjust
- kVA (per phase, average & percent)
- Overcurrent (50 / 51)
- Alarm acknowledge
- Environmental sealed front face
- 6 programmable digital inputs
- Oil pressure (psi, kPa or bar)
- Amps (per phase & average)
- Generator phase sequence
- 2 Programmable digital outputs
- Low coolant temperature
- Controls:
- Serial annunciator module data link
- Reverse Power (kW) (32)
- Lamp test
- Coolant temperature
- Engine cycle crank
- kVAr-hr (total)
- 2 Programmable relay outputs (Form C)
- Generator mounted - rear facing
- 24-volt DC operation
- kVAr (per phase, average & percent)
- Warning/shutdown with common LED indication of shutdowns for:
- kW (per phase, average & percent)
- Reverse Reactive Power (kVAr) (32RV)
- Programmable protective relaying functions:
- Digital indication for:
- High coolant temperature
- Low oil pressure
- Overspeed
- Over / under voltage (27 / 59)
- Customer data link (Modbus RTU)
- DC volts
- Operating hours
- Low coolant level
- kW-hr (total)
- Frequency (Hz)
- Emergency stop
- Power Factor (per phase & average)
- Failure to start (overcrank)
- True RMS AC metering, 3-phase, +/-2% accuracy
Cooling System
- JWAC
- Caterpillar extended life coolant. (Not included with packages without radiator, installed SF44CTS, shipped loose radiators or heat exchangers)
- Radiator fan and fan drive
- Fan and belt guards
- Coolant drain line with valve
- Coolant level sensors. (Not included with packages without radiator)
Exhaust System
- Dry Exhaust Manifold
- Flanged faced outlet(s)
Fuel System
- Fuel cooler; not included with packages without radiator
- Flexible fuel lines - shipped loose
- Fuel priming pump
- Secondary fuel filters
Generators And Attachments
- Generator set packages include: Regulator (CDVR)
- 6 Lead
- Min / max exciter limiter
- LV:
- Reactive droop capability
- Random wound
- Exciter diode monitor
- KVAR/PF modes
- NEMA Class H insulation
- 50 Hz models: IEC standard hole pattern
- Caterpillar's Digital Voltage Regulator (CDVR) includes:
- Note: 1800 frames are form wound, permanent magnet, with winding temp detectors
- Busbar connections, top center mounted, top cable entry
- Internal Excitation
- Winding temperature detectors
- Class H temperature rise at 40C ambient (125C prime/150C standby)
- 3 Phase brushless, salient pole
- 3 Phase voltage sensing
- RFI suppression
Governing System
- Woodward 2301A isochronous governor
Lube System
- Oil drain lines and valve
- Gear type lube oil pump
- Fumes disposal
- Oil filter, filler and dipstick
- Lubricating oil
- Integral lube oil cooler
Mounting System
- Rubber anti-vibration mounts (shipped loose)
- Rails - engine/generator/radiator mounting
Starting / Charging System
- 24 Volt electric starting motor
- Battery and battery rack w/cables
- Battery disconnect switch
General
- Paint - Caterpillar Yellow with high gloss black rails & radiator
- SAE Standard Rotation
- RH Service
- Flywheel and Flywheel housing - SAE No. 00

Optional Equipment:

Air Inlet System
- Remote air inlet adaptors
- Air Inlet protection
- Dual Element air cleaners
Circuit Breakers
- EMAX circuit breakers
- Center posts busbars
- EMAX breakers connections
- Breaker harnesses
- 2000, 2500, 3200 and 4000 Amp, 4 pole, IEC rated circuit breakers
- Controls packaging - Enclosures
- Cable entry options
- 2000, 2500, 3200 and 4000 Amp, 3 pole, IEC rated circuit breakers
- Optional busbar power connections
- Busbar connections
Control Panel
- Auxiliary Boxes
- Customer connection mounting locations
- Ground (Automatically selected)
- Vandle proof panel door
- Customer Interface Options
- Mounting Group - External Box Clips
- Remote speed adjust
- Generator Temperature Monitoring
- Governors
- Annunciator Modules
- Local PC monitoring
Cooling System
- Water level switch gauges
- Heat exchangers
- Optional radiator arrangements
European Certifications
- EU declaration of conformity
- Eurasian conformity (EAC) mark
- European directive genset, DoI (Declaration of Incorporation)
- European Union Certification
Exhaust System
- Through-wall installation kit
- Muffler mounting kits
- Mufflers
- Flexible fittings
Fuel System
- Primary fuel filter
Generators And Attachments
- 380 / 400 / 415 Volts @ 50 Hz, 3 phase, form wound, permanent magnet, No. of leads = 6, pitch= 0.6667
- 380/400/415volts @ 50 Hz, 3 phase, random wound, permanent magnet, No. of leads = 6, pitch= 0.6667
- Generator conversion
- 380/400/415volts @ 50 Hz, 3 phase, random wound, internal excitation, No. of leads = 6, pitch= 0.6667
- Space heater
Instrumentation
- Pyrometer and thermocouples
Lube System
- Electric prelube pumps
- Oil level Reg-1 shallow pan
- Manual prelube sump pumps
Mounting System
- Spring-type vibration isolator
- IBC vibration isolators
Protection System
- Explosion relief valve
Special Tests / Reports
- Neutral grounding connection
- IBC seismic certifications
- Neutral ground-LV
- PGS test report @ 1.0 power factor
- PGS test report @ 0.8 power factor
Starting / Charging Systems
- Ether starting aid
- 24 Volt dual electric starting motor
- 20 Amp battery charger
- Oversize battery set
- Jacket water heaters
- 10 Amp battery chargers
General
- Engine barring group

Gregory Poole Equipment Company

3.9

Based on 46 reviews

review us on

Renee Herndon

21:55 29 Feb 24

Dalton was very helpful, The road construction, however, was not! 😂I would rather have to sand paper an alligators @$$ in a phone booth that to get in that mess again.

Michael Birren

14:58 24 Feb 24

I purchased a used C-15 from a customer of Greg Pool was a running take out. I picked up the engine from the Greg Pool Cat near Nags Head NC. They started they had done all service on this engine stated the hours and all items replaced during the life of engine under their care. I just recently put the engine in my boat after 2 years of building the vessel I find that everything they said about the engine was a LIE!!! Turbo was Bad, After cooler was not updated to the newer version for the C-15 it was missing a terminal Resistor that was clearly stolen off the engine which created a major issue with start up upon installation. Greg Pool Caterpillar stated the hours at 3300 we find out there were 5700 hours. I didn’t do a start up or test run which I regret because i was dealing with a Caterpillar dealer i thought i could trust them. Clearly not Buyers Be Ware if your dealing with Greg Pool Caterpillar in NC. I have 3 of the C-15 engines in my Work boats here in Tampa Fl and my Cat dealership here is Ring power who have done an amazing job to get me going with this Engine. I am very Disappointed in The Caterpillar company for allowing such A dealership to exist.

13:04 22 Feb 24

22:00 18 Feb 24

01:17 16 Feb 24

15:26 23 Sep 23

OLEKSANDR “Alex” Kovalenko

14:27 18 Sep 23

👍

Hunter Elliott

16:17 07 Sep 23

Rick Kelly-Crapse

21:06 25 Aug 23

They had all my parts for my 3208 Cat.Friendly folks at parts counter.

Standard Equipment:

Optional Equipment:

Cat Switchgear

Contact Us Today